Owner's Manual

(:RAFTSMAN

15 GALLON

SKID SPRAYER

Model No,486,24534

CAUTION:

Before using this product,

read this manual and follow all Safety Rules and Operating Instructions.

Sears, Roebuck and Co., Hoffman Estates, IL 60179 U.S.A.

???Safety

???Assembly

???Operation

???Maintenance

???Parts

PRINTED IN U.S.A.

LIMITED ONE YEAR WARRANTY ON

For one year from the date of purchase, when this sprayer is maintained and lubricated according to the operating and maintenance instructions in the owner's manual, Sears will repair any defect in material or workmanship free of charge. If this sprayer is used for commercial or rental purposes, this warranty applies for only 90 days from the date of purchase.

This warranty does not cover repairs necessary because of operator negligence or abuse, including the failure to maintain the equipment according to instructions contained in the owner's manual.

WARRANTY SERVICE IS AVAILABLE BY CONTACTING THE NEAREST SEARS SERVICE CENTER/DEPARTMENT

IN THE UNITED STATES.

This warranty applies only while this product is in the United States.

This warranty gives you specific legal rights, and you may also have other rights which vary from state to state. Sears, Roebuck and Co. D/817 WA. Hoffrnan Estates, Chicago, IL 60179

The model number and serial numbers will be found on a decal attached to the sprayer tank.

You should record both the serial number and the date of purchase and keep in a safe place for future reference.

SERIAL NUMBER:

DATE OF PURCHASE:

Any power equipment can cause injury if operated improperly or if the user does not understand how to operate the equipment. Exercise caution at all times, when using power equipment.

???Read this owners manual carefully before attempting to assemble or operate this sprayer.

???Read instructions and caution notes for handling and mixing of materials purchased for spraying.

???Wear eye and hand protection and protective clothing when handling and applying lawn chemicals.

???Do not spray on windy days.

???Read chemical labels carefully.

2

CARTON CONTENTS

1.Corrosion Resistant Polyethylene Tank

2.12 Volt Motor and 35 PSI Pump

3.12'6"Hose with Handgun

3

1

2

FIGURE 1

CONNECTING TO BATTERY

The sprayer is fully assembled at the factory. The only assembly necessary is to hook up the wiring to a 12 volt power source. The red wire of the two wire set must be

connected to the positive post on the battery, or the "HOT" connection on a switch or ammeter. The brown

wire may be grounded or connected to the negative battery post.

plug to come in contact with positive "HOT"

,_ CAUTION: Never allow negative pin on post on battery. Fire or explosion can result.

NEGATIVE

POST

t

NEGATIVE PIN

12 VOLT TRACTOR BAI-rERY

FIGURE 2

KNOW YOUR SPRAYER

Read this owner's manual and safety rules before operating your sprayer.

Compare the illustrate'onbelow with your sprayer to familiarize yourself with the various controls and their locations,

NOZZLE_

SPRAY GUN TRIGGER

\

SPRAY GUN TRIGGER Turns the flow to the nozzle on or off.

BEFORE STARTING

It Is Important to test the boom and spray gun with plain water before attempting actual spraying. This will enable you to check the sprayer for leaks and to adjust the spray pattern. If a leak should occur, thread tape may be used to better seal the fitting.

HOW TO START YOUR SPRAYER

???Once the sprayer is connected to a power source the pump will start whenever a pressure drop is caused by squeezing the spray gun trigger. A pressure switch on the pump turns the motor on when the system pressure drops below 35 psi.

HOW TO STOP YOUR SPRAYER

???The pump will turn of whenever a pressure buildup to 35 psi is caused by releasing the spray gun trigger.

NOZZLE Adjusts the spray pattern from a fine mist to a straight stream.

USING YOUR SPRAYER

???The spray gun has an adjustable nozzle which allows the spray pattern to be adjusted from a cone shaped fine mist to a straight stream.

???Do not subject the pump to continuous rapid on and off cycling (one second intervals) for long periods of time. This occurs when the spray gun is adjusted for a very low rate of flow.

???Disconnect the sprayer from the power source to conserve energy from the battery during periods of idleness. While the resting sprayer is connected, the pump will run periodically as the system pressure gradually drops below 35 psi.

???Stay clear of flowers, shrubs and evergreen trees when spraying weed control solutions. Avoid contact of the solution with these sensitive plants.

and protective clothing when handling

CAUTION: Wear eye protection, gloves and working with lawn chemicals.

4

CUSTOMER RESPONSIBILITIES

Read and follow the maintenance schedule and the maintenance procedureslisted in this section.

CHECK FOR LOOSE FASTENERS

???Before each use make a thorough visual check of the sprayer for any bolts and nuts which may have loosened. Retighten any loose bolts and nuts.

CLEANING STRAINER

???Periodically clean the strainer in the end of the intake hose at the bottom of the tank. Remove the nylon swivel nut from the hose, pull out the screen and flush it with clear water.

CLEANING TANK

???After each use, fill the tank part way with water, start the sprayer and allow clear water to be pumped through the plumbing system and out through the handgun. Use the handgun to thoroughly wash all internal parts of the tank and the outside of the tank.

???Refill the tank about half full with plain water and a chemical neutralizer and repeat the cleaning instruc- tions above. Flush the entire sprayer with the neutral- izing agent. Follow the chemical manufacturers instructions for disposal of all was h or rinsing water.

Drain all water out of the sprayer, paying special attention to the pump and handgun. These items are especially prone to damage from chemicals and freezing weather.

The sprayer should be winterized before storage by pumping a 50-50 solution of water and R. V. anti- freeze through the entire plumbing. Proper care and maintenance will prolong the life of the sprayer.

5

NOTES

6

REPAIR PARTS FOR 15 GALLON SKID SPRAYER MODEL 486.24534

7

21 8

7

For in-home major brand repair service:

Call 24 hours a day, 7 days a week

1-800-4-MY-HOME" (1-800-469-4663)

Para pedir servicio de reparaci6n a domicilio- 1-800-676-5811

In Canada for all your service and parts needs call - 1-800-665-4455

Au Canada pour tout le service ou les pibces

For the repair or replacement parts you need: Call 7 am - 7 pm, 7 days a week 1-800-366-PART(1-800-366-7278)

Para ordenar piezas con entrega a domicilio - 1-800-659-7084

For the location of a Sears Parts and Repair Center in your area:

Call 24 hours a day, 7 days a week

1-800-488-1222

For information on purchasing a Sears Maintenance Agreement or to inquire about an existing Agreement:

Call 9 am - 5 pm, Monday - Saturday

1-800-827-6655

TheServiceSideofSears"